Consumer Product Safety Commission
New
Electric Heat Tapes Help Prevent Fires:
Safety Alert
CPSC Document #5045
To help prevent fires, the U.S. Consumer Product Safety Commission (CPSC) urges homeowners
(including residents of mobile homes) to replace uncertified heat tapes more than
three years old. Uncertified heat tapes should be replaced with new heat tapes certified
to meet recognized voluntary standards. At the present the following organizations
are certifying heat tapes to meet recognized voluntary standards: Underwriters Laboratories
(UL), the Canadian Standards Association (CSA), and Factory Mutual Research Corporation
(FMRC).
Electric heat tapes are used to keep water pipes from freezing. Heat tapes are usually
installed in attics or underneath porches and homes, especially mobile homes. CPSC
estimates there are about 2,000 fires, 10 deaths, and 100 injuries each year involving
heat tapes. The use of certified heat tapes can help to reduce the frequency of these
fires.
CPSC offers these safety tips for purchasing, installing, and maintaining
electric heat tapes:
-
Replace uncertified heat tapes more than 3 years old with new heat tapes certified to meet recognized voluntary standards. All new heat tapes will have a 3-prong plug.
-
Always plug the 3-prong plug into a 3-prong outlet to make sure the heat tape is grounded.
-
Use a ground-fault circuit-interrupter (GFCI) wherever heat tapes are plugged in.
-
Do not wrap heat tape over itself unless specifically permitted in the manufacturer's instructions.
-
Apply heat tapes directly on the pipe to be protected, never on top of the insulation covering the pipe.
-
Do not cover the heat tape with insulation unless advised by the manufacturer. Use nonflammable insulation such as fiber glass. Do not use foam or vinyl insulation that could catch fire from a failing heat tape.
-
Keep the end-cap sealed and off the ground to prevent water from getting in. Moisture can lead to a fire.
-
Do not use heat tapes designed for water pipes on gutters, driveways, or fuel lines.
-
If heat tape has a thermostat, check instructions to see if the thermostat should be placed against the pipe and covered with insulation or if it should be left hanging and uncovered.
-
Inspect heat tapes each year and replace them if you notice signs of deterioration. Look for discolored surfaces (especially at the plug), charring, cuts or breaks in the insulation, or bare wires.
-
Check installation instructions when you change types or brands of heat tape because different heat tapes have different installation requirements.
Send the link for this page to a friend! Consumers can obtain this publication and additional publication information from the Publications section of CPSC's web site or by sending your publication request to info@cpsc.gov.
This document is in the public domain. It may be reproduced without change in part or whole by an individual or organization without permission. If it is reproduced, however, the Commission would appreciate knowing how it is used. Write the U.S. Consumer Product Safety Commission, Office of Information and Public Affairs, 4330 East West Highway, Bethesda, MD 20814 or send an e-mail to info@cpsc.gov.
The U.S. Consumer Product Safety Commission is charged with protecting the public from unreasonable risks of serious injury or death from more than 15,000 types of consumer products under the agency's jurisdiction. Deaths, injuries and property damage from consumer product incidents cost the nation more than $700 billion annually. The CPSC is committed to protecting consumers and families from products that pose a fire, electrical, chemical, or mechanical hazard or can injure children. The CPSC's work to ensure the safety of consumer products - such as toys, cribs, power tools, cigarette lighters, and household chemicals - contributed significantly to the 30 percent decline in the rate of deaths and injuries associated with consumer products over the past 30 years.
To report a dangerous product or a product-related injury, call CPSC's hotline at (800) 638-2772 or CPSC's teletypewriter at (800) 638-8270, or visit CPSC's web site at www.cpsc.gov/talk.html. To join a CPSC email subscription list, please go to www.cpsc.gov/cpsclist.asp. Consumers can obtain this release and recall information at CPSC's Web site at www.cpsc.gov.
Back to Many
Heat Tapes Can Pose a Fire Hazard
Back to Articles
